1.氣水分離器、冷凝器和沼氣管道中的冷凝水應定期排放。排水時應防止甲烷泄漏。
1. Condensate in gas-water separator, condenser and biogas pipeline shall be discharged regularly. Methane leakage shall be prevented during drainage.
2.脫硫裝置應定期排污。
2. Desulfurization device shall be regularly discharged.
3.脫硫裝置中的脫硫劑應定期再生或更換。冬季氣溫低于10℃時，應采取保溫措施。
3. The desulfurizer in the desulfurizer shall be regenerated or replaced regularly. When the temperature is lower than 10 ℃ in winter, thermal insulation measures shall be taken.
4.定期觀察儲氣罐的儲氣量和壓力，并做好記錄。
4. Regularly observe the gas storage capacity and pressure of the gas tank and make records.
5.沼氣要充分利用，多余的沼氣要用火炬燃燒。
5. The biogas should be fully utilized, and the surplus biogas should be burned with a torch.
6.儲氣罐的水封應保持設計的水封液位高度。夏季應補充淡水，冬季氣溫低于0℃時應采取防凍措施。
6. The water seal of the gas storage tank shall maintain the designed water seal level. Fresh water should be added in summer, and antifreeze measures should be taken when the temperature is lower than 0 ℃ in winter.
7.每半年測量一次儲氣罐水封池中的水的酸堿度。當酸堿度小于6時，更換水。
7. Measure the pH of the water in the water-sealed tank of the gas storage tank every half a year. When the pH is less than 6, replace the water.
8.檢修沼氣凈化裝置或更換脫硫劑時，應依靠旁路來維持沼氣輸配系統的正常運行。
8. When overhauling the biogas purification device or replacing the desulfurizer, the normal operation of the biogas transmission and distribution system should be maintained by the bypass.
沼氣凈化的維護保養：
Maintenance of biogas purification:
1.應定期檢查儲氣罐、燃?xì)夤艿朗欠裥孤?/div>
1. Regularly check whether the gas storage tank and gas pipeline leak.
2.儲氣罐外表面的油漆或涂層應定期重新涂覆。
2. The paint or coating on the outer surface of the air tank shall be reapplied regularly.
3.儲氣罐的提升裝置應定期檢查并添加潤滑油。
3. The lifting device of the air tank should be regularly checked and added with lubricating oil.
4.寒冷地區，每年冬季前應對儲氣庫水封防凍設施進行檢修。
4. In cold areas, the water seal and antifreeze facilities of the gas storage should be overhauled before each winter.
5.儲氣罐應每510年清洗和修理一次。
5. The air storage tank should be cleaned and repaired every 5 to 10 years.
沼氣凈化的操作：
Safe operation of biogas purification:
1.操作人員上下儲氣罐進行巡視或操作維護時，必須穿防靜電工作服，不得穿帶釘鞋。
1. The operator must wear anti-static work clothes and shall not wear spiked shoes when going up and down the gas storage tank for patrol inspection or operation and maintenance.
2.清洗、維護和拆卸儲氣罐時，必須采取措施，并嚴格遵守規定。
2. When cleaning, maintaining and disassembling the gas storage tank, safety measures must be taken and regulations must be strictly observed.
3.儲氣罐內低水位時嚴禁排空鐘罩。
3. When the water level in the air tank is low, it is forbidden to empty the bell cover.
4.操作人員到儲氣罐維修或操作時，嚴禁在柜體頂板上行走。
4. When the operator goes to the gas storage tank for maintenance or operation, it is forbidden to walk on the top plate of the cabinet.
魯公網安備37011202000764號號 網站地圖XMLTXT
企業二維碼
2023-02-15
